• Something wrong with this record ?

Continuous production of n-butanol by Clostridium pasteurianum DSM 525 using suspended and surface-immobilized cells

A. Gallazzi, B. Branska, F. Marinelli, P. Patakova,

. 2015 ; 216 (-) : 29-35. [pub] 20151022

Language English Country Netherlands

Document type Journal Article, Research Support, Non-U.S. Gov't

Persistent link   https://www.medvik.cz/link/bmc16028089

For n-butanol production by Clostridium pasteurianum DSM 525, a modified reinforced Clostridium medium was used, where glucose was alternated with glycerol and two kinds of continuous fermentation were tested using suspended and surface immobilized cells on corn stover pieces. A steady state, with butanol productivity of 4.2g/Lh, was reached during the packed-bed continuous fermentation at a dilution rate of 0.44h(-1). The average n-butanol concentration, yield and the ratio of n-butanol/liquid by-products were 10.4g/L, 33 % and 2.5, respectively. Unexpectedly, during continuous fermentation with suspended cells, at a dilution rate of 0.01h(-1), steady-state was not achieved and regular oscillations occurred in all measured variables, i.e. concentrations of glycerol, products and the number of cells stained with the fluorescent dyes carboxy fluorescein diacetate and propidium iodide. A possible explanation for oscillatory/steady-state behavior of suspended/surface-attached cells, respectively, may be specific butanol toxicity (toxicity per cell), which was higher/lower in respective cases, and which might be caused by lower/higher cell numbers respectively in both systems.

References provided by Crossref.org

000      
00000naa a2200000 a 4500
001      
bmc16028089
003      
CZ-PrNML
005      
20161025093955.0
007      
ta
008      
161005s2015 ne f 000 0|eng||
009      
AR
024    7_
$a 10.1016/j.jbiotec.2015.10.008 $2 doi
024    7_
$a 10.1016/j.jbiotec.2015.10.008 $2 doi
035    __
$a (PubMed)26471284
040    __
$a ABA008 $b cze $d ABA008 $e AACR2
041    0_
$a eng
044    __
$a ne
100    1_
$a Gallazzi, Alessandro $u Department of Biotechnology, University of Chemistry and Technology, Prague, Czech Republic; Department of Biotechnology and Life Sciences, University of Insubria, Varese, Italy; "The Protein Factory" Research Center, Politecnico of Milano, ICRM CNR Milano and University of Insubria, Varese, Italy.
245    10
$a Continuous production of n-butanol by Clostridium pasteurianum DSM 525 using suspended and surface-immobilized cells / $c A. Gallazzi, B. Branska, F. Marinelli, P. Patakova,
520    9_
$a For n-butanol production by Clostridium pasteurianum DSM 525, a modified reinforced Clostridium medium was used, where glucose was alternated with glycerol and two kinds of continuous fermentation were tested using suspended and surface immobilized cells on corn stover pieces. A steady state, with butanol productivity of 4.2g/Lh, was reached during the packed-bed continuous fermentation at a dilution rate of 0.44h(-1). The average n-butanol concentration, yield and the ratio of n-butanol/liquid by-products were 10.4g/L, 33 % and 2.5, respectively. Unexpectedly, during continuous fermentation with suspended cells, at a dilution rate of 0.01h(-1), steady-state was not achieved and regular oscillations occurred in all measured variables, i.e. concentrations of glycerol, products and the number of cells stained with the fluorescent dyes carboxy fluorescein diacetate and propidium iodide. A possible explanation for oscillatory/steady-state behavior of suspended/surface-attached cells, respectively, may be specific butanol toxicity (toxicity per cell), which was higher/lower in respective cases, and which might be caused by lower/higher cell numbers respectively in both systems.
650    _2
$a n-butanol $x metabolismus $7 D020001
650    _2
$a techniky vsádkové kultivace $7 D061249
650    _2
$a bioreaktory $7 D019149
650    _2
$a biotechnologie $x metody $7 D001709
650    _2
$a imobilizované buňky $x cytologie $x metabolismus $x ultrastruktura $7 D018914
650    _2
$a Clostridium $x cytologie $x metabolismus $x ultrastruktura $7 D003013
650    _2
$a fermentace $7 D005285
650    _2
$a odpadní produkty $x analýza $7 D014866
650    _2
$a kukuřice setá $x chemie $7 D003313
655    _2
$a časopisecké články $7 D016428
655    _2
$a práce podpořená grantem $7 D013485
700    1_
$a Branska, Barbora $u Department of Biotechnology, University of Chemistry and Technology, Prague, Czech Republic.
700    1_
$a Marinelli, Flavia $u Department of Biotechnology and Life Sciences, University of Insubria, Varese, Italy; "The Protein Factory" Research Center, Politecnico of Milano, ICRM CNR Milano and University of Insubria, Varese, Italy.
700    1_
$a Patakova, Petra $u Department of Biotechnology, University of Chemistry and Technology, Prague, Czech Republic. Electronic address: petra.patakova@vscht.cz.
773    0_
$w MED00002556 $t Journal of biotechnology $x 1873-4863 $g Roč. 216, č. - (2015), s. 29-35
856    41
$u https://pubmed.ncbi.nlm.nih.gov/26471284 $y Pubmed
910    __
$a ABA008 $b sig $c sign $y a $z 0
990    __
$a 20161005 $b ABA008
991    __
$a 20161025094408 $b ABA008
999    __
$a ok $b bmc $g 1166403 $s 952719
BAS    __
$a 3
BAS    __
$a PreBMC
BMC    __
$a 2015 $b 216 $c - $d 29-35 $e 20151022 $i 1873-4863 $m Journal of biotechnology $n J Biotechnol $x MED00002556
LZP    __
$a Pubmed-20161005

Find record

Citation metrics

Archiving options