Time-resolved cryo electron microscopy (TRCEM) has emerged as a powerful technique for transient structural characterization of isolated biomacromolecular complexes in their native state within the time scale of seconds to milliseconds. For TRCEM sample preparation, microfluidic device [9] has been demonstrated to be a promising approach to facilitate TRCEM biological sample preparation. It is capable of achieving rapidly aqueous sample mixing, controlled reaction incubation, and sample deposition on electron microscopy (EM) grids for rapid freezing. One of the critical challenges is to transfer samples to cryo-EM grids from the microfluidic device. By using microspraying method, the generated droplet size needs to be controlled to facilitate the thin ice film formation on the grid surface for efficient data collection, while not too thin to be dried out before freezing, i.e., optimized mean droplet size needs to be achieved. In this work, we developed a novel monolithic three dimensional (3D) annular gas-assisted microfluidic sprayer using 3D MEMS (MicroElectroMechanical System) fabrication techniques. The microsprayer demonstrated dense and consistent microsprays with average droplet size between 6-9 μm, which fulfilled the above droplet size requirement for TRCEM sample preparation. With droplet density of around 12-18 per grid window (window size is 58×58 μm), and the data collectible thin ice region of >50% total wetted area, we collected ~800-1000 high quality CCD micrographs in a 6-8 hour period of continuous effort. This level of output is comparable to what were routinely achieved using cryo-grids prepared by conventional blotting and manual data collection. In this case, weeks of data collection process with the previous device [9] has shortened to a day or two. And hundreds of microliter of valuable sample consumption can be reduced to only a small fraction.

Center for Integrated Electronics Rensselaer Polytechnic Institute Troy NY 12180

Division of Translational Medicine Wadsworth Center New York State Department of Health Albany NY 12201

Division of Translational Medicine Wadsworth Center New York State Department of Health Albany NY 12201 ; CEITEC Masaryk University Brno Czech Republic

Division of Translational Medicine Wadsworth Center New York State Department of Health Albany NY 12201 ; Department of Microbiology and Immunology Cairo University Cairo Egypt

See more in PubMed

Berriman J, Unwin N. Analysis of transient structures by cryo-microscopy combined with rapid mixing of spray droplets. Ultramicroscopy. 1994;56:241–252. PubMed

White HD, Walker ML, Trinick J. A computer-controlled spraying-freezing apparatus for millisecond time-resolution electron cryomicroscopy. J. Struct. Biol. 1998;121:306–313. PubMed

Tittor J, Paula S, Subramaniam S, Heberle J, Henderson R, Oesterhelt D. Proton translocation by bacteriorhodopsin in the absence of substantial conformational changes. J. Mol. Biol. 2002;319:555–565. PubMed

Frank J. Three-dimensional electron microscopy of macromolecular assemblies. Oxford; New York: 2006.

Menetret JF, Hofmann W, Schroder RR, Rapp G, Goody RS. Time-resolved cryo-electron microscopic study of the dissociation of actomyosin induced by photolysis of photolabile nucleotides. J. Mol. Biol. 1991;219:139–144. PubMed

Subramaniam S, Gerstein M, Oesterhelt D, Henderson R. Electron Diffraction Analysis of Structural Changes in the Photocycle of Bacteriorhodopsin. EMBO J. 1993;12:1–8. PubMed PMC

Unwin N. Acetylcholine receptor channel imaged in the open state. Nature. 1995;373:37–43. PubMed

Frederik PM, Sommerdijk N. Spatial and temporal. resolution in cryo-electron microscopy - A scope for nano-chemistry [Review]. Current Opinion in Colloid & Interface Science. 2005;10:245–249.

Lu Z, Shaikh TR, Barnard D, Meng X, Mohamed H, Yassin A, Mannella CA, Agrawal RK, Lu T-M, Wagenknecht T. Monolithic microfluidic mixing-spraying devices for time-resolved cryo-electron microscopy. J. Struct. Biol. 2009;168:388–395. PubMed PMC

Lu Z, McMahon J, Mohamed J,H, Barnard D, Shaikh TR, Mannella CA, Wagenknecht T, Lu T. Passive microfluidic device for submillisecond mixing. Sensors & Actuators: B. Chemical. 2010;144:301–309. PubMed PMC

Gad-el-Hak M. The MEMS Handbook. Second Edition. Taylor & Francis Group, LLC; 2006. MEMS Applications. chapter 10.

Percin G, Khuri-Yakub BT. Piezoelectric droplet ejector for ink-jet printing of fluids and solid particles. Review of Scientific Instruments. 2003;74:1120–1127.

Xu Q, Zhou Z, Zhu J, Feng Y, Lin D, Du G. Piezoelectrically actuated array microjet for biomedical purpose. Indian Journal of Pure & Applied Physics. 2007;45:273–277.

Deng W, Klemic JF, Li X, Reed MA, Gomez A. Increase of electrospray throughput using multiplexed microfabricated sources for the scalable generation of monodisperse droplets. Aerosol Science. 2006;37:696–714.

Baik S, Blanchard JP, Corradini ML. Development of Micro-Diesel Injector Nozzles via Microelectromechanical Systems Technology and Effects on Spray Characteristics. Journal of Engineering for Gas Turbines and Power. 2003;125:427–434.

Rajan R, Pandit AB. Correlations to Predict Droplet Size in Ultrasonic Atomization. Ultrasonics. 2001;39:235–255. PubMed

Endo I, Nagamune T. Nano/Micro Biotechnology. Springer-Verlag; Berlin Heidelberg: 2010. Surface Acoustic Wave Atomizer and Electrostatic Deposition.

Kim W, Guo M, Yang P, Wang D. Microfabricated Monolithic Multinozzle Emitters for Nanoelectrospray Mass Spectrometry. Anal. Chem. 2007;79:3703–3707. PubMed

Yang Jing-Tang, Huang Ker-Jer, Chen Alex C. Microfabrication and Laser Diagnosis of Pressure-Swirl Atomizers. Journal of Microelectromechanical Systems. 2004;13:843–850.

Naik N, Courcimault C, Hunter H, Berg J, Lee J, Naeli K, Wright T, Allen M, Brand O, Glezer A, King W. Microfluidics for generation and characterization of liquid and gaseous micro- and nanojets. Sensors and Actuators A. 2007;134:119–127.

Liu H. Science and Engineering of Droplets: Fundamentals and Applications. Noyes Publications; Bracknell: 2000.

Wang P, Nalamasu O, Ghoshal R, Ghoshal R, Schaper CD, Li A, Lu T. Novel photocurable epoxy siloxane polymers for photolithography and imprint lithography applications. J. Vac. Sci. Technol. B. 2008;26:244–248.

White HD, Thirumurugan K, Walker ML, Trinick J. A second generation apparatus for time-resolved electron cryo-microscopy using stepper motors and electrospray. J. Struct. Biol. 2003;144:246–252. PubMed

Blaha G, Stelz U, Spahn CMT, Agrawal RK, Frank J, Nierhaus KH. Preparation of functional ribosomal complexes and effect of buffer conditions on tRNA positions observed by cryoelectron microscopy [Review]. RNA-LigandInteract. Method Enzymol. 2000;317:292–309. PubMed

Grassucci RA, Taylor DJ, Frank J. Preparation of macromolecular complexes for cryo-electron microscopy. Nat. Protoc. 2007;2:3239–3246. PubMed PMC