Directing the organization of cells into a tissue with defined architectures is one use of biomaterials for regenerative medicine. To this end, hydrogels are widely investigated as they have mechanical properties similar to native soft tissues and can be formed in situ to conform to a defect. Herein, we describe the development of porous hydrogel tubes fabricated through a two-step polymerization process with an intermediate microsphere phase that provides macroscale porosity (66.5%) for cell infiltration. These tubes were investigated in a spinal cord injury model, with the tubes assembled to conform to the injury and to provide an orientation that guides axons through the injury. Implanted tubes had good apposition and were integrated with the host tissue due to cell infiltration, with a transient increase in immune cell infiltration at 1 week that resolved by 2 weeks post injury compared to a gelfoam control. The glial scar was significantly reduced relative to control, which enabled robust axon growth along the inner and outer surface of the tubes. Axon density within the hydrogel tubes (1744 axons/mm2) was significantly increased more than 3-fold compared to the control (456 axons/mm2), with approximately 30% of axons within the tube myelinated. Furthermore, implantation of hydrogel tubes enhanced functional recovery relative to control. This modular assembly of porous tubes to fill a defect and directionally orient tissue growth could be extended beyond spinal cord injury to other tissues, such as vascular or musculoskeletal tissue. STATEMENT OF SIGNIFICANCE: Tissue engineering approaches that mimic the native architecture of healthy tissue are needed following injury. Traditionally, pre-molded scaffolds have been implemented but require a priori knowledge of wound geometries. Conversely, hydrogels can conform to any injury, but do not guide bi-directional regeneration. In this work, we investigate the feasibility of a system of modular hydrogel tubes to promote bi-directional regeneration after spinal cord injury. This system allows for tubes to be cut to size during surgery and implanted one-by-one to fill any injury, while providing bi-directional guidance. Moreover, this system of tubes can be broadly applied to tissue engineering approaches that require a modular guidance system, such as repair to vascular or musculoskeletal tissues.

Department of Biomedical Engineering University of Michigan Ann Arbor MI 48105 USA

Department of Biomedical Engineering University of Michigan Ann Arbor MI 48105 USA; Department of Chemical Engineering University of Michigan Ann Arbor MI USA

Department of Biomedical Engineering University of Michigan Ann Arbor MI 48105 USA; Department of Nonwovens and Nanofibrous Materials Technical University of Liberec Studentska 1402 2 Liberec 461 17 Czech Republic

Institute for Memory Impairments and Neurological Disorders University of California Irvine CA USA; Sue and Bill Gross Stem Cell Research Center University of California Irvine CA USA; Department of Anatomy and Neurobiology University of California Irvine CA USA; Department of Physical Medicine and Rehabilitation University of California Irvine CA USA

See more in PubMed

Xu T, Zhao W, Zhu JM, Albanna MZ, Yoo JJ, Atala A, Complex heterogeneous tissue constructs containing multiple cell types prepared by inkjet printing technology, Biomaterials 34(1) (2013) 130–9. PubMed

Mapili G, Lu Y, Chen S, Roy K, Laser-layered microfabrication of spatially patterned functionalized tissue-engineering scaffolds, J Biomed Mater Res B Appl Biomater 75(2) (2005) 414–24. PubMed

Raineteau O, Schwab ME, Plasticity of motor systems after incomplete spinal cord injury, Nat Rev Neurosci 2(4) (2001) 263–73. PubMed

Anderson KD, Cowan RE, Horsewell J, Facilitators and Barriers to Spinal Cord Injury Clinical Trial Participation: Multi-National Perspective of People Living with Spinal Cord Injury, J Neurotrauma 33(5) (2016) 493–9. PubMed

Basso DM, Beattie MS, Bresnahan JC, Graded histological and locomotor outcomes after spinal cord contusion using the NYU weight-drop device versus transection, Exp Neurol 139(2) (1996) 244–56. PubMed

Peterson SL, Anderson AJ, Complement and spinal cord injury: traditional and non-traditional aspects of complement cascade function in the injured spinal cord microenvironment, Exp Neurol 258 (2014)35–47. PubMed

Galvan MD, Luchetti S, Burgos AM, Nguyen HX, Hooshmand MJ, Hamers FP, Anderson AJ, Deficiency in complement C1q improves histological and functional locomotor outcome after spinal cord injury, J Neurosci 28(51) (2008) 13876–88. PubMed PMC

Beck KD, Nguyen HX, Galvan MD, Salazar DL, Woodruff TM, Anderson AJ, Quantitative analysis of cellular inflammation after traumatic spinal cord injury: evidence for a multiphasic inflammatory response in the acute to chronic environment, Brain 133(Pt 2) (2010) 433–47. PubMed PMC

Pawar K, Cummings BJ, Thomas A, Shea LD, Levine A, Pfaff S, Anderson AJ, Biomaterial bridges enable regeneration and re-entry of corticospinal tract axons into the caudal spinal cord after SCI: Association with recovery of forelimb function, Biomaterials 65 (2015) 1–12. PubMed PMC

Rajnicek A, Britland S, McCaig C, Contact guidance of CNS neurites on grooved quartz: influence of groove dimensions, neuronal age and cell type, J Cell Sci 110 ( Pt 23) (1997) 2905–13. PubMed

Miller C, Jeftinija S, Mallapragada S, Synergistic effects of physical and chemical guidance cues on neurite alignment and outgrowth on biodegradable polymer substrates, Tissue Eng 8(3) (2002) 367–78. PubMed

Ford MC, Bertram JP, Hynes SR, Michaud M, Li Q, Young M, Segal SS, Madri JA, Lavik EB, A macroporous hydrogel for the coculture of neural progenitor and endothelial cells to form functional vascular networks in vivo, Proc Natl Acad Sci U S A 103(8) (2006) 2512–7. PubMed PMC

McClendon MT, Stupp SI, Tubular hydrogels of circumferentially aligned nanofibers to encapsulate and orient vascular cells, Biomaterials 33(23) (2012) 5713–22. PubMed PMC

Xu CY, Inai R, Kotaki M, Ramakrishna S, Aligned biodegradable nanofibrous structure: a potential scaffold for blood vessel engineering, Biomaterials 25(5) (2004) 877–86. PubMed

Sarkar S, Dadhania M, Rourke P, Desai TA, Wong JY, Vascular tissue engineering: microtextured scaffold templates to control organization of vascular smooth muscle cells and extracellular matrix, Acta Biomater 1(1) (2005) 93–100. PubMed

Kobayashi M, Lei NY, Wang Q, Wu BM, Dunn JC, Orthogonally oriented scaffolds with aligned fibers for engineering intestinal smooth muscle, Biomaterials 61 (2015) 75–84. PubMed PMC

Choi JS, Lee SJ, Christ GJ, Atala A, Yoo JJ, The influence of electrospun aligned poly(epsilon-caprolactone)/collagen nanofiber meshes on the formation of self-aligned skeletal muscle myotubes, Biomaterials 29(19) (2008) 2899–906. PubMed

Chen S, Nakamoto T, Kawazoe N, Chen G, Engineering multi-layered skeletal muscle tissue by using 3D microgrooved collagen scaffolds, Biomaterials 73 (2015) 23–31. PubMed

Orr SB, Chainani A, Hippensteel KJ, Kishan A, Gilchrist C, Garrigues NW, Ruch DS, Guilak F, Little D, Aligned multilayered electrospun scaffolds for rotator cuff tendon tissue engineering, Acta Biomater 24 (2015) 117–26. PubMed PMC

Wang L, Wu Y, Guo B, Ma PX, Nanofiber Yarn/Hydrogel Core-Shell Scaffolds Mimicking Native Skeletal Muscle Tissue for Guiding 3D Myoblast Alignment, Elongation, and Differentiation, ACS Nano 9(9) (2015) 9167–79. PubMed

Xie J, Li X, Lipner J, Manning CN, Schwartz AG, Thomopoulos S, Xia Y, “Aligned-to-random” nanofiber scaffolds for mimicking the structure of the tendon-to-bone insertion site, Nanoscale 2(6) (2010) 923–6. PubMed PMC

Arcaute K, Mann BK, Wicker RB, Fabrication of Off-the-Shelf Multilumen Poly(Ethylene Glycol) Nerve Guidance Conduits Using Stereolithography, Tissue Eng Part C Methods 17(1) (2011) 27–38. PubMed

Colello RJ, Chow WN, Bigbee JW, Lin C, Dalton D, Brown D, Jha BS, Mathern BE, Lee KD, Simpson DG, The incorporation of growth factor and chondroitinase ABC into an electrospun scaffold to promote axon regrowth following spinal cord injury, J Tissue Eng Regen Med (2013). PubMed

Francis NL, Hunger PM, Donius AE, Riblett BW, Zavaliangos A, Wegst UG, Wheatley MA, An ice-templated, linearly aligned chitosan-alginate scaffold for neural tissue engineering, J Biomed Mater Res A 101(12) (2013) 3493–503. PubMed

Gelain F, Panseri S, Antonini S, Cunha C, Donega M, Lowery J, Taraballi F, Cerri G, Montagna M, Baldissera F, Vescovi A, Transplantation of nanostructured composite scaffolds results in the regeneration of chronically injured spinal cords, ACS Nano 5(1) (2011) 227–36. PubMed

Gros T, Sakamoto JS, Blesch A, Havton LA, Tuszynski MH, Regeneration of long-tract axons through sites of spinal cord injury using templated agarose scaffolds, Biomaterials 31(26) (2010) 6719–29. PubMed

Moore K, MacSween M, Shoichet M, Immobilized concentration gradients of neurotrophic factors guide neurite outgrowth of primary neurons in macroporous scaffolds, Tissue Eng 12(2) (2006) 267–78. PubMed

Tsai EC, Dalton PD, Shoichet MS, Tator CH, Matrix inclusion within synthetic hydrogel guidance channels improves specific supraspinal and local axonal regeneration after complete spinal cord transection, Biomaterials 27(3) (2006) 519–33. PubMed

Yao L, Daly W, Newland B, Yao S, Wang W, Chen BK, Madigan N, Windebank A, Pandit A, Improved axonal regeneration of transected spinal cord mediated by multichannel collagen conduits functionalized with neurotrophin-3 gene, Gene Ther 20(12) (2013) 1149–57. PubMed

Gunther MI, Weidner N, Muller R, Blesch A, Cell-seeded alginate hydrogel scaffolds promote directed linear axonal regeneration in the injured rat spinal cord, Acta Biomater 27 (2015) 140–50. PubMed

Bareyre FM, Kerschensteiner M, Raineteau O, Mettenleiter TC, Weinmann O, Schwab ME, The injured spinal cord spontaneously forms a new intraspinal circuit in adult rats, Nat Neurosci 7(3) (2004) 269–77. PubMed

Hejcl A, Urdzikova L, Sedy J, Lesny P, Pradny M, Michalek J, Burian M, Hajek M, Zamecnik J, Jendelova P, Sykova E, Acute and delayed implantation of positively charged 2-hydroxyethyl methacrylate scaffolds in spinal cord injury in the rat, J Neurosurg Spine 8(1) (2008) 67–73. PubMed

Nomura H, Zahir T, Kim H, Katayama Y, Kulbatski I, Morshead CM, Shoichet MS, Tator CH, Extramedullary chitosan channels promote survival of transplanted neural stem and progenitor cells and create a tissue bridge after complete spinal cord transection, Tissue Eng Part A 14(5) (2008) 649–65. PubMed

Sugai K, Nishimura S, Kato-Negishi M, Onoe H, Iwanaga S, Toyama Y, Matsumoto M, Takeuchi S, Okano H, Nakamura M, Neural stem/progenitor cell-laden microfibers promote transplant survival in a mouse transected spinal cord injury model, J Neurosci Res 93(12) (2015) 1826–38. PubMed

Zamani F, Amani-Tehran M, Latifi M, Shokrgozar MA, Zaminy A, Promotion of spinal cord axon regeneration by 3D nanofibrous core-sheath scaffolds, J Biomed Mater Res A 102(2) (2014) 506–13. PubMed

Dumont CM, Munsell MK, Carlson MA, Cummings BJ, Anderson A, Shea LD, Spinal progenitor-laden bridges support earlier axon regeneration following spinal cord injury, Tissue Eng Part A (2018). PubMed PMC

Thomas AM, Kubilius MB, Holland SJ, Seidlits SK, Boehler RM, Anderson AJ, Cummings BJ, Shea LD, Channel density and porosity of degradable bridging scaffolds on axon growth after spinal injury, Biomaterials 34(9) (2013) 2213–20. PubMed PMC

Thomas AM, Seidlits SK, Goodman AG, Kukushliev TV, Hassani DM, Cummings BJ, Anderson AJ, Shea LD, Sonic hedgehog and neurotrophin-3 increase oligodendrocyte numbers and myelination after spinal cord injury, Integr Biol (Camb) 6(7) (2014) 694–705. PubMed PMC

Tuinstra HM, Aviles MO, Shin S, Holland SJ, Zelivyanskaya ML, Fast AG, Ko SY, Margul DJ, Bartels AK, Boehler RM, Cummings BJ, Anderson AJ, Shea LD, Multifunctional, multichannel bridges that deliver neurotrophin encoding lentivirus for regeneration following spinal cord injury, Biomaterials 33(5) (2012) 1618–26. PubMed PMC

Tuinstra HM, Margul DJ, Goodman AG, Boehler RM, Holland SJ, Zelivyanskaya ML, Cummings BJ, Anderson AJ, Shea LD, Long-term characterization of axon regeneration and matrix changes using multiple channel bridges for spinal cord regeneration, Tissue Eng Part A 20(5-6) (2014) 1027–37. PubMed PMC

Smith DR, Margul DJ, Dumont CM, Carlson MA, Munsell MK, Johnson M, Cummings BJ, Anderson AJ, Shea LD, Combinatorial lentiviral gene delivery of pro-oligodendrogenic factors to improve myelination of regenerating axons after spinal cord injury, Biotechnol Bioeng (2018). PubMed PMC

Cao H, Liu T, Chew SY, The application of nanofibrous scaffolds in neural tissue engineering, Adv Drug Deliv Rev 61(12) (2009) 1055–64. PubMed

Ahadian S, Ramon-Azcon J, Estili M, Liang X, Ostrovidov S, Shiku H, Ramalingam M, Nakajima K, Sakka Y, Bae H, Matsue T, Khademhosseini A, Hybrid hydrogels containing vertically aligned carbon nanotubes with anisotropic electrical conductivity for muscle myofiber fabrication, Sci Rep 4(2014) 4271. PubMed PMC

Ramon-Azcon J, Ahadian S, Estili M, Liang X, Ostrovidov S, Kaji H, Shiku H, Ramalingam M, Nakajima K, Sakka Y, Khademhosseini A, Matsue T, Dielectrophoretically aligned carbon nanotubes to control electrical and mechanical properties of hydrogels to fabricate contractile muscle myofibers, Adv Mater 25(29) (2013) 4028–34. PubMed

Madden LR, Mortisen DJ, Sussman EM, Dupras SK, Fugate JA, Cuy JL, Hauch KD, Laflamme MA, Murry CE, Ratner BD, Proangiogenic scaffolds as functional templates for cardiac tissue engineering, Proc Natl Acad Sci U S A 107(34) (2010) 15211–6. PubMed PMC

Abu-Rub MT, Billiar KL, van Es MH, Knight A, Rodriguez BJ, Zeugolis DI, McMahon S, Windebank AJ, Pandit A, Nano-textured self-assembled aligned collagen hydrogels promote directional neurite guidance and overcome inhibition by myelin associated glycoprotein, Soft Matter 7 (2011)2770–2781.

Assuncao-Silva RC, Gomes ED, Sousa N, Silva NA, Salgado AJ, Hydrogels and Cell Based Therapies in Spinal Cord Injury Regeneration, Stem Cells Int 2015 (2015) 948040. PubMed PMC

Kubinova S, Horak D, Hejcl A, Plichta Z, Kotek J, Proks V, Forostyak S, Sykova E, SIKVAV-modified highly superporous PHEMA scaffolds with oriented pores for spinal cord injury repair, J Tissue Eng Regen Med 9(11) (2015) 1298–309. PubMed

Liu C, Huang Y, Pang M, Yang Y, Li S, Liu L, Shu T, Zhou W, Wang X, Rong L, Liu B, Tissue-engineered regeneration of completely transected spinal cord using induced neural stem cells and gelatin-electrospun poly (lactide-co-glycolide)/polyethylene glycol scaffolds, PLoS One 10(3) (2015) e0117709. PubMed PMC

Du Y, Ghodousi M, Qi H, Haas N, Xiao W, Khademhosseini A, Sequential assembly of cellladen hydrogel constructs to engineer vascular-like microchannels, Biotechnol Bioeng 108(7) (2011) 1693–703. PubMed PMC

Rose JC, Gehlen DB, Haraszti T, Kohler J, Licht CJ, De Laporte L, Biofunctionalized aligned microgels provide 3D cell guidance to mimic complex tissue matrices, Biomaterials 163 (2018) 128–141. PubMed

Rivet CJ, Zhou K, Gilbert RJ, Finkelstein DI, Forsythe JS, Cell infiltration into a 3D electrospun fiber and hydrogel hybrid scaffold implanted in the brain, Biomatter 5 (2015) e1005527. PubMed PMC

Jin J, Limburg S, Joshi SK, Landman R, Park M, Zhang Q, Kim HT, Kuo AC, Peripheral nerve repair in rats using composite hydrogel-filled aligned nanofiber conduits with incorporated nerve growth factor, Tissue Eng Part A 19(19-20) (2013) 2138–46. PubMed PMC

Yang Z, Zhang A, Duan H, Zhang S, Hao P, Ye K, Sun YE, Li X, NT3-chitosan elicits robust endogenous neurogenesis to enable functional recovery after spinal cord injury, Proc Natl Acad Sci U S A 112(43)(2015)13354–9. PubMed PMC

Madigan NN, McMahon S, O’Brien T, Yaszemski MJ, Windebank AJ, Current tissue engineering and novel therapeutic approaches to axonal regeneration following spinal cord injury using polymer scaffolds, Respir Physiol Neurobiol 169(2) (2009) 183–99. PubMed PMC

Han S, Wang B, Jin W, Xiao Z, Chen B, Xiao H, Ding W, Cao J, Ma F, Li X, Yuan B, Zhu T, Hou X, Wang J, Kong J, Liang W, Dai J, The collagen scaffold with collagen binding BDNF enhances functional recovery by facilitating peripheral nerve infiltrating and ingrowth in canine complete spinal cord transection, Spinal Cord 52(12) (2014) 867–73. PubMed

Mothe AJ, Tam RY, Zahir T, Tator CH, Shoichet MS, Repair of the injured spinal cord by transplantation of neural stem cells in a hyaluronan-based hydrogel, Biomaterials 34(15) (2013) 3775–83. PubMed

Underwood RA, Usui ML, Zhao G, Hauch KD, Takeno MM, Ratner BD, Marshall AJ, Shi X, Olerud JE, Fleckman P, Quantifying the effect of pore size and surface treatment on epidermal incorporation into percutaneously implanted sphere-templated porous biomaterials in mice, J Biomed Mater Res A 98(4) (2011) 499–508. PubMed PMC

Griffin DR, Weaver WM, Scumpia PO, Di Carlo D, Segura T, Accelerated wound healing by injectable microporous gel scaffolds assembled from annealed building blocks, Nat Mater 14(7) (2015) 737–44. PubMed PMC

Shikanov A, Smith RM, Xu M, Woodruff TK, Shea LD, Hydrogel network design using multifunctional macromers to coordinate tissue maturation in ovarian follicle culture, Biomaterials 32(10) (2011) 2524–31. PubMed PMC

Margul DJ, Park J, Boehler RM, Smith DR, Johnson MA, McCreedy DA, He T, Ataliwala A, Kukushliev TV, Liang J, Sohrabi A, Goodman AG, Walthers CM, Shea LD, Seidlits SK, Reducing neuroinflammation by delivery of IL-10 encoding lentivirus from multiple-channel bridges, Bioeng Transl Med 1(2) (2016) 136–148. PubMed PMC

McCreedy DA, Margul DJ, Seidlits SK, Antane JT, Thomas RJ, Sissman GM, Boehler RM, Smith DR, Goldsmith SW, Kukushliev TV, Lamano JB, Vedia BH, He T, Shea LD, Semi-automated counting of axon regeneration in poly(lactide co-glycolide) spinal cord bridges, J Neurosci Methods 263 (2016) 15–22. PubMed PMC

Karimi A, Shojaei A, Tehrani P, Mechanical properties of the human spinal cord under the compressive loading, J Chem Neuroanat 86 (2017) 15–18. PubMed

Oakland RJ, Hall RM, Wilcox RK, Barton DC, The biomechanical response of spinal cord tissue to uniaxial loading, Proc Inst Mech Eng H 220(4) (2006) 489–92. PubMed

Ozawa H, Matsumoto T, Ohashi T, Sato M, Kokubun S, Comparison of spinal cord gray matter and white matter softness: measurement by pipette aspiration method, J Neurosurg 95(2 Suppl) (2001) 221–4. PubMed

Dumont CM, Park J, Shea LD, Controlled release strategies for modulating immune responses to promote tissue regeneration, J Control Release 219 (2015) 155–66. PubMed PMC

Day JR, David A, Kim J, Farkash EA, Cascalho M, Milasinovic N, Shikanov A, The impact of functional groups of poly(ethylene glycol) macromers on the physical properties of photo-polymerized hydrogels and the local inflammatory response in the host, Acta Biomater 67 (2018) 42–52. PubMed PMC

Dumont CM, Margul DJ, Shea LD, Tissue Engineering Approaches to Modulate the Inflammatory Milieu following Spinal Cord Injury, Cells Tissues Organs 202(1-2) (2016) 52–66. PubMed PMC

Cregg JM, DePaul MA, Filous AR, Lang BT, Tran A, Silver J, Functional regeneration beyond the glial scar, Exp Neurol 253 (2014) 197–207. PubMed PMC

Stirling DP, Liu S, Kubes P, Yong VW, Depletion of Ly6G/Gr-1 leukocytes after spinal cord injury in mice alters wound healing and worsens neurological outcome, J Neurosci 29(3) (2009) 753–64. PubMed PMC

Shechter R, London A, Varol C, Raposo C, Cusimano M, Yovel G, Rolls A, Mack M, Pluchino S, Martino G, Jung S, Schwartz M, Infiltrating blood-derived macrophages are vital cells playing an anti-inflammatory role in recovery from spinal cord injury in mice, PLoS Med 6(7) (2009) e1000113. PubMed PMC

Donnelly DJ, Popovich PG, Inflammation and its role in neuroprotection, axonal regeneration and functional recovery after spinal cord injury, Exp Neurol 209(2) (2008) 378–88. PubMed PMC