In the production of fermented feed, each crop can be contaminated with a variety of microorganisms that may produce natural pollutants. Biogenic amines, mycotoxins, and undesirable organic acids can decrease health feed safety. The aim of this study was to compare the counts of microorganisms, levels of biogenic amines, and the mycotoxins in forage legumes, and also to compare the occurrence of microorganisms and levels of mycotoxins in green fodder and subsequently produced silage and the influence of additives on the content of natural harmful substances in silage. The experimental plot was located in Troubsko and Vatín, in the Czech Republic. Two varieties of Medicago sativa and one variety of Trifolium pratense were compared. Green fodder and subsequently produced silage reaching up to 23% of dry matter were evaluated and prepared using a bio-enzymatic additive and a chemical additive. Green fodder of Medicago sativa was more contaminated by Enterococci than Trifolium pratense fodder. The obvious difference was determined by the quality of silage leachate. The silage prepared from Medicago sativa fodder was more contaminated with butyric acid. Fungi were present in higher counts in the anaerobic environment of green fodder and contaminated it with zearalenone and deoxynivalenol. Lower counts of fungi were found in silage, although the zearalenone content did not change. Lower content of deoxynivalenol was detected in silage, compared with green fodder. Silages treated with a chemical additive were found not to contain butyric acid. Lower ethanol content was determined, and the tendency to reduce the risk of biogenic amines occurrence was evident. The additives proved to have no influence on the content of mycotoxins.

Faculty of AgriSciences Mendel University in Brno Zemedelska 1 61300 Brno Czech Republic

Research Institute for Fodder Crops Ltd Troubsko Zahradni 1 66441 Troubsko Czech Republic

Zobrazit více v PubMed

Dolezal P., Dvoracek J., Loucka R., Mikyska F., Mudrik Z., Boberfeld O., Prokes K., Prikryl J., Skladanka J., Strakova E., et al. Konzervace Krmiv a Jejich Využití ve Výživě Zvířat. 1st ed. Vydavatelství Petr Baštan; Olomouc, Czech Republic: 2012. p. 308.

Seppala A., Heikkila T., Maki M., Miettinen H., Rinne M. Controlling aerobic stability of grass silage-based total mixed rations. Anim. Feed Sci. Technol. 2013;179:54–60. doi: 10.1016/j.anifeedsci.2012.11.011. DOI

Scherer R., Gerlach K., Sudekum K.H. Biogenic amines and gamma-amino butyric acid in silages: Formation, occurrence and influence on dry matter intake and ruminant production. Anim. Feed Sci. Technol. 2015;210:1–16. doi: 10.1016/j.anifeedsci.2015.10.001. DOI

Santos S.M.H. Biogenic amines: Their importance in foods. Int. J. Food Microbiol. 1996;29:213–231. doi: 10.1016/0168-1605(95)00032-1. PubMed DOI

Nishino N., Hattori H., Wada H., Touno E. Biogenic amine production in grass, maize and total mixed ration silages inoculated with Lactobacillus casei or Lactobacillus buchneri. J. Appl. Microbiol. 2007;103:325–332. doi: 10.1111/j.1365-2672.2006.03244.x. PubMed DOI

Selwet M., Galbas M., Porzucek F., Koczorowski M., Pociejowska M. Effects of the method of alfalfa ensiling on the content of biogenic amines and numbers of some strains of Lactobacillus spp. Med. Weter. 2013;69:358–362.

Steidlova S., Kalac P. Biogenic amines in grass and clover-grass silages. Collect. Sci. Papers Fac. Agric. Ceske Budejovice Ser. Anim. Sci. 2002;19:153–160.

Steidlova S., Kalac P. Levels of biogenic amines in maize silages. Anim. Feed Sci. Technol. 2002;102:197–205. doi: 10.1016/S0377-8401(02)00217-1. DOI

Skladanka J., Nedelnik J., Aadam V., Dolezal P., Moravcova H., Dohnal V. Forage as a primary source of mycotoxins in animal diets. Int. J. Environ. Res. Public Health. 2011;8:37–50. doi: 10.3390/ijerph8010037. PubMed DOI PMC

Reverberi M., Ricelli A., Zjalic S., Fabbri A.A., Fanelli C. Natural functions of mycotoxins and control of their biosynthesis in fungi. Appl. Microbiol. Biotechnol. 2010;87:899–911. doi: 10.1007/s00253-010-2657-5. PubMed DOI

Gravesen S., Frisvad J.C., Samson R.A. Microfungi. Munksgaard; Copenhagen, Denmark: 1994. p. 168.

Lillehoj E.B., Diener U.L., Asquith R.L., Dickens J.W. Southern Cooperative Series Bulletin. Volume 279. Kentucky Agricultural Experiment Station; Lexington, KY, USA: 1983. Aflatoxin and Aspergillus Flavus in Corn; p. 27.

Vasatkova A., Krizova S., Krystofova O., Adam V., Zeman L., Beklova M., Kizek R. Effect of naturally mouldy wheat or fungi administration on metallothioneins-3 level in brain tissues of rats. Neuroendocrinol. Lett. 2010;30:163–168. PubMed

Dohnal V., Jezkova A., Jun D., Kuca K. Metabolic pathways of T-2 toxin. Curr. Drug Metab. 2008;9:77–82. PubMed

Hartman M. Stanovení neutrálnmích těkavých látek v silážích a senážích plynovou chromatografií. Živočišná Výroba. 1974;4:209–216.

Driehuis F., Elferink Oude S.J.W.H. The impact of the quality of silage on animal health and food safety: A review. Vet. Quart. 2000;22:212–216. doi: 10.1080/01652176.2000.9695061. PubMed DOI

Gollop N., Zakin V., Weinberg Z.G. Antibacterial activity of lactic acid bacteria included in inoculants for silage and in silages treated with these inoculants. J. Appl. Microbiol. 2005;98:662–666. doi: 10.1111/j.1365-2672.2004.02504.x. PubMed DOI

Van Os M., Van Wikselaar P.G., Spoelstra S.F. Formation of biogenic amines in well fermented grass silages. J. Agric. Sci. 1996;127:97–107. doi: 10.1017/S0021859600077418. DOI

Bover-Cid S., Hugas M., Izquierdo-Pulido M., Vidal-Carou M.C. Reduction of biogenic amine formation using a negative amino acid-decarboxylase starter culture for fermentation of fuet sausage. J. Food Prot. 2000;63:237–243. doi: 10.4315/0362-028X-63.2.237. PubMed DOI

Tveit B., Lingaas F., Svendsen M., Sjaastad O.V. Etiology of acetonemia in Norwegian cattle. 1. Effect of ketogenic silage, season, energy level, and genetic factors. J. Dairy Sci. 1992;75:2421–2432. doi: 10.3168/jds.S0022-0302(92)78003-5. PubMed DOI

Steidlova S., Kalac P. The effects of lactic acid bacteria inoculants and formic acid on the formation of biogenic amines in grass silages. Arch. Anim. Nutr. 2004;58:245–254. doi: 10.1080/00039420410001701378. PubMed DOI

McDonald P., Macpherson H.T., Watt J.A. The effect of histamine on silage dry-matter intake. Grass Forage Sci. 1963;18:230–232. doi: 10.1111/j.1365-2494.1963.tb00354.x. DOI

Okamoto M., Waldo D.R., Miller R.W., Moore L.A. Histamine levels in forages and dry matter intake of heifers. J. Dairy Sci. 1964;47:1231–1236. doi: 10.3168/jds.S0022-0302(64)88887-1. DOI

Holzer M., Mayrhuber E., Danner H., Braun R. The role of Lactobacillus buchneri in forage preservation. Trends Biotechnol. 2003;21:282–287. doi: 10.1016/S0167-7799(03)00106-9. PubMed DOI

Herrmann C., Heiermann M., Idler C. Effects of ensiling, silage additives and storage period on methane formation of biogas crops. Bioresour. Technol. 2011;102:5153–5161. doi: 10.1016/j.biortech.2011.01.012. PubMed DOI

Magan N., Aldred D. Post-harvest control strategies: Minimizing mycotoxins in the food chain. Int. J. Food Microbiol. 2007;119:131–139. doi: 10.1016/j.ijfoodmicro.2007.07.034. PubMed DOI

Scudamore K.A., Livesey C.T. Occurrence and significance of mycotoxins in forage crops and silage: A review. J. Sci. Food Agric. 1998;77:1–17. doi: 10.1002/(SICI)1097-0010(199805)77:1<1::AID-JSFA9>3.0.CO;2-4. DOI

Alonso V.A., Pereyra C.M., Keller L.A.M., Dalcero A.M., Rosa C.A.R., Chiacchiera S.M., Cavaglieri L.R. Fungi and mycotoxins in silage: An overview. J. Appl. Microbiol. 2013;115:637–643. doi: 10.1111/jam.12178. PubMed DOI