The present study aims to estimate the maximum oil yield of hulled sunflower seed samples in a uniaxial process under a load of 40 kN and speed of 4 mm/min. The oil samples were assessed for their quality parameters and spectra curves within the wavelength range of 325-600 nm. The results show that heating temperatures in the range of 40 °C to 80 °C increased the oil output; however, a maximum oil yield of 48.869 ± 6.023% with a minimum energy of 533.709 ± 65.644 J at the fifth repeated pressing was obtained from the unheated sample compared to the heated samples. The peroxide values ranged from 6.898 ± 0.144 to 7.290 ± 0.507 meq O2/kg, acid values from 1.043 ± 0.166 to 1.998 ± 0.276 mg KOH/g oil and free fatty acid values from 0.521 ± 0.083 to 0.999 ± 0.138 mg KOH/g oil, which were within the recommended quality threshold. There were significant spectral differences among the oil samples. A single absorbance peak was observed at 350 nm for all oil samples, indicating low levels of pigment molecules in the oil. The study revealed the need for repeated pressings to recover the considerable residual oil remaining in the seedcake after the first pressing.

Department of Mechanical Engineering Faculty of Engineering Czech University of Life Sciences Prague 165 20 Prague Czech Republic

Zobrazit více v PubMed

Stevenson D.G., Eller F.J., Wang L., Jane J.L., Inglett G.E. Oil and Tocopherol content and composition of pumpkin seed oil in 12 cultivars. J. Agric. Food Chem. 2007;55:4005–4013. doi: 10.1021/jf0706979. PubMed DOI

Chatepa L.E.C., Uluko H., Masamba K. Comparison of oil quality extracted from selected conventional and non conventional sources of vegetable oil from Malawi. Afr. J. Biotechnol. 2019;18:171–180.

Gotor A.A., Rhazi L. Effects of refining process on sunflower oil minor components: A review. OCL. 2016;23:D207. doi: 10.1051/ocl/2016007. DOI

Teixeira M.R., Nogueira R., Nunes L.M. Quantitative assessment of the valorization of used cooking oils in 23 countries. Waste Manag. 2018;78:611–620. doi: 10.1016/j.wasman.2018.06.039. PubMed DOI

Mitrea L., Teleky B.-E., Leopold L.-F., Nemes S.-A., Plamada D., Dulf F.V., Pop I.-D., Vodnar D.C. The physicochemical properties of five vegetable oils exposed at high temperature for a short-time-interval. J. Food Compost. Anal. 2022;106:104305. doi: 10.1016/j.jfca.2021.104305. DOI

Ng T.-T., So P.K., Zheng B.O., Yao Z.-P. Rapid screening of mixed edible oils and gutter oils by matrix-assisted laser desorption/ionization mass spectrometry. Anal. Chim. Acta. 2015;884:70–76. doi: 10.1016/j.aca.2015.05.013. PubMed DOI

Rifna E.J., Pandiselvam R., Kothakota A., Rao K.V.S., Dwivedi M., Kumar M., Thirumdas R., Ramesh S.V. Advanced process analytical tools for identification of adulterants in edible oils—A review. Food Chem. 2022;369:130898. doi: 10.1016/j.foodchem.2021.130898. PubMed DOI

Dimitrijevic A., Horn R. Sunflower hybrid breeding: From markers to genomic selection. Front. Plant Sci. 2018;8:2238. doi: 10.3389/fpls.2017.02238. PubMed DOI PMC

Martinez A.L., Quiroz F.J., Carrera A.D. Detection of Plasmopara halstedii in sunflower seeds: A case study using molecular testing. J. Saudi Soc. Agric. Sci. 2021;20:395–400.

Dean C. Coconut oil for Alzheimer’s. J. Am. Acad. Physician Assist. 2012;25:1–5.

Sandupama P., Munasinghe D., Jayasinghe M. Coconut oil as a therapeutic treatment for alzheimer’s disease: A review. J. Future Foods. 2022;2:41–52. doi: 10.1016/j.jfutfo.2022.03.016. DOI

Kumar K.A., Viswanathan K. Study of UV transmission through a few edible oils and chicken oil. J. Spectrosc. 2013;2013:540417.

Liu R., Lu M., Zhang Z., Chang M., Wang X. Evaluation of the antioxidant properties of micronutrients in different vegetable oils. Eur. J. Lipid Sci. Technol. 2020;122:1900079. doi: 10.1002/ejlt.201900079. DOI

Cai Z., Li K., Lee W.J., Reaney M.T.J., Zhang N., Wang Y. Recent progress in the thermal treatment of oilseeds and oil oxidative stability: A review. Fundam. Res. 2021;6:767–784. doi: 10.1016/j.fmre.2021.06.022. DOI

Savoire R. Screw pressing applications to oilseeds. Ref. Modul. Food Sci. 2017 doi: 10.1016/B978-0-08-100596-5.21191-8. DOI

Savoire R., Lanoiselle J.L., Vorobiev E. Mechanical continuous oil expression from oilseeds. A review. Food Bioprocess Technol. 2013;6:1–16. doi: 10.1007/s11947-012-0947-x. DOI

Singh K.K., Wiesenborn D., Kangas N., Tostenson K. Screw pressing characteristics of dehulled crambe seed. Trans. ASABE. 2004;47:199–204. doi: 10.13031/2013.15848. DOI

Bogaert L., Mathieu H., Mhemdi H., Vorobiev E. Characterization of oilseeds mechanical expression in an instrumented pilot screw press. Ind. Crops. Prod. 2018;121:106–113. doi: 10.1016/j.indcrop.2018.04.039. DOI

Mpagalile J.J., Clarke B. Effect of processing parameters on coconut oil expression efficiencies. Int. J. Food Sci. Nutr. 2005;56:125–132. doi: 10.1080/09637480500082058. PubMed DOI

Karaj S., Muller J. Optimizing mechanical oil extraction of Jatropha curcas L. seeds with respect to press capacity, oil recovery and energy efficiency. Ind. Crops. Prod. 2011;34:1010–1016. doi: 10.1016/j.indcrop.2011.03.009. DOI

Romuli S., Karaj S., Latif S., Muller J. Performance of mechanical co-extraction of Jatropha curcas L. kernels with rapeseed, maize or soybean with regard to oil recovery, press capacity and product quality. Ind. Crops. Prod. 2017;104:81–90. doi: 10.1016/j.indcrop.2017.03.035. DOI

Divisova M., Herak D., Kabutey A., Sigalingging R., Svatonova T. Deformation curve characteristics of rapeseeds and sunflower seeds under compression loading. Sci. Agric. Bohem. 2014;45:180–186.

Munson-Mcgee S.H. D-optimal experimental designs for uniaxial expression. J. Food Process Eng. 2014;37:248–256. doi: 10.1111/jfpe.12080. DOI

Demirel C., Kabutey A., Herák D., Sedlaček A., Mizera Č., Dajbych O. Using Box–Behnken Design Coupled with Response Surface Methodology for Optimizing Rapeseed Oil Expression Parameters under Heating and Freezing Conditions. Processes. 2022;10:490. doi: 10.3390/pr10030490. DOI

Gupta R.K., Das S.K. Fracture resistance of sunflower seed and kernel to compressive loading. J. Food Eng. 2000;46:1–8. doi: 10.1016/S0260-8774(00)00061-3. DOI

Kabutey A., Mizera Č., Dajbych O., Hrabě P., Herák D., Demirel C. Modelling and Optimization of Processing Factors of Pumpkin Seeds Oil Extraction under Uniaxial Loading. Processes. 2021;9:540. doi: 10.3390/pr9030540. DOI

Kabutey A., Herak D., Mizera C., Hrabe P. Compressive loading experiment of non-roasted bulk oil palm kernels at varying pressing factors. Int. Agrophysics. 2018;32:357–363. doi: 10.1515/intag-2017-0020. DOI

Erum Z., Rehana S., Mehwish A.H., Anjum Y. Study of Physicochemical Properties of Edible Oil and Evaluation of Frying Oil Quality by Fourier Transform-Infrared (FT-IR) Spectroscopy. Arab. J. Chem. 2014;10:3870–3876.

Herchi W., Ammar K.B., Bouali I., Abdallah I.B., Guetet A., Boukhchina S. Heating effects on physicochemical characteristics and antioxidant activity of flaxseed hull oil (Linum usitatissimum L.) Food Sci. Technol. 2016;36:97–102. doi: 10.1590/1678-457X.0109. DOI

Tang T.S. 8 Analysis of oleochemicals. Oleochem. Manu. Appl. 2001;4:227.

de Souza T.R.P., Olenka L., Peternella W.S. A study of degradation in vegetable oils by exposure to sunlight using Fourier Transform Infrared Spectroscopy. Mater. Sci. Appl. 2020;11:678–691. doi: 10.4236/msa.2020.1110046. DOI

Amadi B.A., Lele K.C., Duru M.K.C. Extraction and characterization of vegetable oils from legume and palmae; using African Oil Bean (Pentaclethra macrophylla) and ‘Akwu Ojukwu’ (Elais guineensis) respectively. Am. J. Biol. Life Sci. 2013;1:7–10.

Katkade M.B., Syed H.M., Andhale R.R., Farooqui A.S. Comparative study of physicochemical properties of different edible vegetable oils. J. Sci. Agric. Eng. 2018;8:235–238.

Adeyanju J.A., Ogunlakin G.O., Adekunle A.A., Alawode G.E., Majekolagbe O.S. Optimization of oil extraction from coconut using response surface methodology. J. Chem. Pharm. Res. 2016;8:374–381.

Ifa L., Syarif T., Sartia S., Juliani J., Nurdjannah N., Kusuma H.S. Techno-economics of coconut coir bioadsorbent utilization on free fatty acid level reduction in crude palm oil. Heliyon. 2022;8:e09146. doi: 10.1016/j.heliyon.2022.e09146. PubMed DOI PMC

Di Pietro M.E., Mannu A., Mele A. NMR determination of free fatty acids in vegetable oils. Processes. 2020;8:410. doi: 10.3390/pr8040410. DOI

Cammerer B., Kroh L.W. Shelf life of linseeds and peanuts in relation to roasting. Food Sci. Technol. 2009;42:545–549. doi: 10.1016/j.lwt.2008.08.003. DOI

Adejumo B.A., Inaede S.G., Adamu T.S. Effect of moisture content on the yield and characteristics of oil from valiculatum and V. calycinium. Pac. Sci. 2013;48:458–463.

Okene E.O., Evbuomwan B.O. Solvent extraction and characteristics of oil from coconut seeds using alternative solvents. Int. J. Eng. Technol. Res. 2014;2:135–138.

Atinafu D.G., Bedemo B. Estimation of total free fatty acid and cholesterol content in some commercial edible oils in Ethiopia, Bahir DAR. J. Cereals Oilseeds. 2011;2:71–76. doi: 10.5897/JCO11.025. DOI

Lobo V., Patil A., Phatak A., Chandra N. Free radicals, antioxidants and functional foods: Impact on human health. Pharmacogn. Rev. 2010;4:118–126. doi: 10.4103/0973-7847.70902. PubMed DOI PMC

Konuskan D.B., Arslan M., Oksuz A. Physicochemical properties of cold pressed sunflower, peanut, rapeseed, mustard and olive oils grown in the Eastern Mediterranean region. Saudi J. Biol. Sci. 2019;26:340–344. doi: 10.1016/j.sjbs.2018.04.005. PubMed DOI PMC

Codex Alimentarius Commission . Fats, Oils and Related Products. 2nd ed. Volume 8 Food and Agriculture Organizaation of the United Nations; Rome, Italy: 2001.

ISI . Indian Standard Institute. ISI; New Delhi, India: 1966. Indian Standard Methods for Analysis of Oilseeds. IS: 3579.

Blahovec J. Agromatereials Study Guide. Czech University of Life Sciences Prague; Prague, Czech Republic: 2008.

Keneni Y.G., Hvoslef-Eide A.K.T., Marchetti J.M. Mathematical modelling of the drying kinetics of Jatropha curcas L. seed. Ind. Crops. Prod. 2019;132:12–20. doi: 10.1016/j.indcrop.2019.02.012. DOI

Niu L., Li J., Chen M.S., Xu Z.F. Determination of oil contents in Sacha inchi (Plukenetia volubilis) seeds at different developmental stages by two methods: Soxhlet extraction and time-domain nuclear magnetic resonance. Ind. Crops. Prod. 2014;56:187–190. doi: 10.1016/j.indcrop.2014.03.007. DOI

Mohammadpour H., Sadrameli S.M., Eslami F., Asoodeh A. Optimization of ultrasound-assisted extraction of Moringa peregrina oil with response surface methodology and comparison with Soxhlet method. Ind. Crops. Prod. 2019;131:106–116. doi: 10.1016/j.indcrop.2019.01.030. DOI

Gürdil A.K.G., Kabutey A., Selvi K.C., Hrabe P., Herak D., Frankova A. Investigation of heating and freezing pretreatments of mechanical, chemical and spectral properties of bulk sunflower seeds and oil. Processes. 2020;8:411. doi: 10.3390/pr8040411. DOI

Deli S., Farah Masturah M., Tajul Aris Y., Wan Nadiah W.A. The effects of physical parameters of the screw press oil expeller on oil yield from Nigella sativa L. seeds. Int. Food Res. J. 2011;18:1367–1373.

Chanioti S., Constantina T. Optimization of ultrasound-assisted extraction of oil from olive pomace using response surface technology: Oil recovery, unsaponifiable matter, total phenol content and antioxidant activity. LWT Food Sci. Technol. 2017;79:178–189. doi: 10.1016/j.lwt.2017.01.029. DOI

Lysiak G. Fracture toughness of pea: Weibull analysis. J. Food Eng. 2007;83:436–443. doi: 10.1016/j.jfoodeng.2007.03.034. DOI

Demirel C., Kabutey A., Herák D., Hrabě P., Mizera Č., Dajbych O. Optimizing Uniaxial Oil Extraction of Bulk Rapeseeds: Spectrophotometric and Chemical Analyses of the Extracted Oil under Pretreatment Temperatures and Heating Intervals. Processes. 2021;9:1755. doi: 10.3390/pr9101755. DOI

Orozco F.D.A., Sousa A.C., Araujo M.C.U., Domini C.E. A new flow UV-Vis kinetics spectrophotometric method based on photodegradative reaction for determining the oxidative stability of biodiesel. Fuel. 2020;26:116–197.

Statsoft Inc. STATISTICA for Windows. Statsoft Inc.; Tulsa, OK, USA: 2013.

Khan L.M., Hanna M.A. Expression of oil from oilseeds—A Review. J. Agric. Eng. Res. 1983;28:495–503. doi: 10.1016/0021-8634(83)90113-0. DOI

Li W.G., Sun X.L., Zu Y.G., Zhao X.H. Optimization peony seed oil extraction process at suitable temperature and physicochemical property analysis. Bull. Botan. Res. 2020;40:73–78.

Deng R., Gao J., Yi J., Liu P. Could peony seeds oil become a high-quality edible vegetable oils? The nutritional and phytochemistry profiles, extraction, health benefits, safety and value-added-products. Food Res. Int. 2022;156:111200. doi: 10.1016/j.foodres.2022.111200. PubMed DOI

Dodoo D., Adjei F., Tulashie S.K., Adukpoh K.E., Agbolegbe R.E., Gawou G., Manu G.P. Quality evaluation of different repeatedly heated vegetable oils for deep-frying of yam fries. Meas. Food. 2022;7:100035. doi: 10.1016/j.meafoo.2022.100035. DOI

Hoffmann G. The Chemistry and Technology of Edible Oils and Fats and Their High-Fat Products. Academic Press; New York, NY, USA: 1989. pp. 63–68.

Reuber M. M.S. Thesis. Iowa State University; Ames, IA, USA: 1992. New Technologies for processing Crambe abyssinica.

Singh K.K., Wiesenborn D.P., Tostenson K., Kangas N. Influence of moisture content and cooking on screw pressing of crambe seed. JAOCS. 2002;79:165–170. doi: 10.1007/s11746-002-0452-3. DOI

Choo W.S., Birch E.J., Dufour J.P. Physicochemical and stability characteristics of flaxseed oils during pan-heating. JAOCS. 2007;84:735–740. doi: 10.1007/s11746-007-1096-7. DOI

Ajai A.I., Adedokun T.A., Inobeme A., Jacob J.O. Determination of physicochemical properties of selected vegetable oils in Minna. FUW Trends Sci. Technol. J. 2016;1:475–478.

Vicentini-Polette C.M., Ramos P.R., Goncalves C.B., De Oliveira A.L. Determination of free fatty acids in crude vegetable oil samples obtained by high-pressure processes. Food Chem. X. 2021;12:100166. doi: 10.1016/j.fochx.2021.100166. PubMed DOI PMC

Eke-Ejiofor J., Beleya E.A., Allen J.E. Effect of variety on the quality parameters of crude soybean oil. Am. J. Food Sci. Technol. 2021;9:69–75.

Nduka J.K.C., Omozuwa P.O., Imanah O.E. Effect of heating on the physiological properties of selected vegetable oils. Arab. J. Chem. 2021;14:103063. doi: 10.1016/j.arabjc.2021.103063. DOI

Tiffour I., Dehbi A., Mourad A.-H.I., Belfedal A. Synthesis and characterization of a new organic semiconductor material. Mater. Chem. Phys. 2016;178:49–56. doi: 10.1016/j.matchemphys.2016.04.054. DOI

Gonzalez M.F., Barbero G.F., Alvarez J.A., Ruiz A., Palma M., Ayuso J. Authentication of virgin olive oil by a novel curve resolution approach combined with visible spectroscopy. Food Chem. 2007;220:331–336. doi: 10.1016/j.foodchem.2016.10.015. PubMed DOI

Wang H., Xin Y., Wan X. Spectral detection technology of vegetable oil: Spectral analysis of porphyrins and terpenoids. Spectrochim. Acta Part A Mol. Biomol. Spectrosc. 2021;261:119965. doi: 10.1016/j.saa.2021.119965. PubMed DOI

Altman D.G., Bland J.M. Standard deviations and standard errors. BJM. 2005;331:903. doi: 10.1136/bmj.331.7521.903. PubMed DOI PMC

Assessment of Quality and Efficiency of Cold-Pressed Oil from Selected Oilseeds