Nutrient deficiency induces a variety of cellular responses, including an increase in lipid accumulation in microalgae. Nitrogen starvation is the most studied deprivation. Here, we determine the effects of phosphorus and sulfur limitation on lipid accumulation in Chlorella vulgaris. A set of 9 experiments were performed, varying the initial concentration of these nutrients (set to 0, 50, and 100% of their original composition in Bold's basal medium). According to our results, the variation of P and S modified the specific growth rate, lag phase, and cell generation time. The ratio of 50%P and 0%S significantly increased the total lipid concentration. The fatty acid profile was dominated by C16:0, C18:0, and C18:1; a considerable increase in C20:5 was observed with 0%P and 50%S and 0%P and 100%S. Regarding neutral lipids, the response surface methodology (RSM) indicates that the maximum was observed when S was between 40 and 60% and P was between 95 and 100%. Therefore, the enhanced production of lipids caused by P and S limitation may contribute to the efficient oil production useful for algal biofuels.
Centrifugation is the most commonly used method for harvesting autotrophically produced microalgae, but it is expensive due to high energy demands. With the aim of reducing these costs, we tested electrocoagulation with iron electrodes for harvesting Chlorella vulgaris. During extensive lab-scale experiments, the following factors were studied to achieve a high harvesting efficiency and a low iron content in the harvested biomass: electric charge, initial biomass concentration, pH, temperature, agitation intensity, residual salt content and electrolysis time. A harvesting efficiency greater than 95% was achieved over a broad range of conditions and the residual iron content in the biomass complied with legislative requirements for food. Using electrocoagulation as the pre-concentration step prior to centrifugation, total energy costs were reduced to 0.136 kWh/kg of dry biomass, which is less than 14% of that for centrifugation alone. Our data show that electrocoagulation is a suitable and cost-effective method for harvesting microalgae.
- MeSH
- biomasa MeSH
- Chlorella vulgaris * MeSH
- elektrokoagulace MeSH
- elektrolýza MeSH
- flokulace MeSH
- mikrořasy * MeSH
- Publikační typ
- časopisecké články MeSH
NOVELTY STATEMENT: Ecologically suitable methods for the decontamination of liquid radioactive waste or radioactively contaminated areas are becoming more and more important due to the pollution of the planet. We believe that phytoremediation of radionuclides using microalgae is one of the optimal ecological methods to decontamination of radioactive waste. Microalgae as unicellular organisms have a number of advantages over the other organisms used in bioremediation-high level of tolerance to the environment, fast growth rates, high tolerance to various pH levels, etc. In this study, we used 3 different strains of microalgae for phytoremediation of various radionuclides (137Cs, 60Co, 241Am, and 239Pu). This research was focused on ex situ phytoremediation of radionuclides using microalgae at various pH levels of radioactively contaminated solutions. Due to the ability of microalgae to adapt to sometimes even extreme pH values, this research may be interesting for many institutions and researchers dealing with more environmentally friendly methods of decontamination of radioactive waste.
OBJECTIVE: Desalination of cheese whey by electrodialysis yields saline wastewater (SWW). The goal was to test this as the basis of a culture medium and to prove experimentally the concept that it was a suitable resource for heterotrophic cultivation of the freshwater green microalga Chlorella vulgaris. RESULTS: Optimization of glucose concentration, nitrogen source and medium salinity for microalgal growth was first carried out in defined medium (DM) and shake flasks. These results were then adopted in shake flask cultivation experiments using pre-treated SWW medium (PSWW). Subsequently, microalgal growth under optimized conditions was tested in bioreactors. Various media such as DM, PSWW and diluted PSWW (DPSWW) were compared. Volumetric biomass productivities decreased in the order DM (0.371 g L-1 h-1, urea) > DPSWW (0.315 g L-1 h-1, soy peptone) > PSWW (0.152 g L-1 h-1, soy peptone). Although biomass productivities in DPSWW and PSWW media were significantly lower than in DM, these media required the addition of only 66 and 33% of DM N sources, respectively. No other added DM component was necessary in (D)PSWW to achieve microalgal growth. CONCLUSIONS: Although the optimized cultivation of freshwater microalgae on alternative medium based on SWW resulted in biomass productivities lower than those on DM, the required addition of N sources was also lower. Potentially lower production costs of Chlorella biomass and the meaningful use of SWW are the main outcomes of this work.
The aim of the study was to identify the optimum cultivation conditions for the microalgal growth and lipid production of the oleaginous microalga Chlorella pyrenoidosa Chick (IPPAS C2). Moreover, an appropriate NO3- concentration in the cultivation medium for maximized lipid accumulation was determined. The experimental design involved a biphasic cultivation strategy with an initial biomass accumulating phase under optimized light (400 μmol/m2 per s), temperature (25 °C), and elevated CO2 concentration in the air mixture (3%), followed by a mid-elevated CO2 concentration (0.5%) for lipid induction. The highest lipid yields of 172.47 ± 18.1 and 179.65 ± 25.4 mg/L per day were detected for NO3- concentrations of 100 and 150 mg/L. The optimization approach presented here led not only to the maximization of lipid yield but also to the development of a biphasic cultivation strategy easily applicable to the cultivation process without the necessity for algal cell harvesting between the first and second cultivation phases.
- MeSH
- biomasa MeSH
- Chlorella růst a vývoj metabolismus MeSH
- dusičnany metabolismus MeSH
- fotobioreaktory MeSH
- kultivační média metabolismus MeSH
- lipidy biosyntéza MeSH
- mikrořasy růst a vývoj metabolismus MeSH
- oxid uhličitý metabolismus MeSH
- techniky vsádkové kultivace MeSH
- teplota MeSH
- Publikační typ
- časopisecké články MeSH
In this study, a novel harvesting emulsion (HEM) consisting of cooking oil in an aqueous solution of cetyltrimethylammonium bromide (CTAB) was tested for the harvesting of a technologically important microalga, Chlorella vulgaris. The influence of HEM dose, biomass and bovine serum albumin (BSA) (model interferer compound) on harvesting efficiency (E) were studied. The HEM E was over 90% at pH 10 (0.33% (v/v) cooking oil, 6.7 mg/L of CTAB) and 12 (0.13% (v/v) cooking oil, 2.7 mg/L of CTAB). Harvesting efficiencies at pH 4 and 7 were < 73.5% due to the absence of precipitate formation. Bovine serum albumin (10 mg/L) increased the HEM dose necessary to achieve E ˃ 90% by 1.2 (pH 10), and 3 fold (pH 12). By manipulating the dose of HEM and pH, the method of harvesting (flocculation/sedimentation or flotation) was adjustable depending on the technological requirements.
- MeSH
- biomasa MeSH
- Chlorella vulgaris * MeSH
- flokulace MeSH
- mikrořasy * MeSH
- povrchově aktivní látky MeSH
- vaření MeSH
- voda MeSH
- Publikační typ
- časopisecké články MeSH
Microalgae accumulate bioavailable selenium-containing amino acids (Se-AAs), and these are useful as a food supplement. While this accumulation has been studied in phototrophic algal cultures, little data exists for heterotrophic cultures. We have determined the Se-AAs content, selenium/sulfur (Se/S) substitution rates, and overall Se accumulation balance in photo- and heterotrophic Chlorella cultures. Laboratory trials revealed that heterotrophic cultures tolerate Se doses ∼8-fold higher compared to phototrophic cultures, resulting in a ∼2-3-fold higher Se-AAs content. In large-scale experiments, both cultivation regimes provided comparable Se-AAs content. Outdoor phototrophic cultures accumulated up to 400 μg g-1 of total Se-AAs and exhibited a high level of Se/S substitution (5-10%) with 30-60% organic/total Se embedded in the biomass. A slightly higher content of Se-AAs and ratio of Se/S substitution was obtained for a heterotrophic culture in pilot-scale fermentors. The data presented here shows that heterotrophic Chlorella cultures provide an alternative for Se-enriched biomass production and provides information on Se-AAs content and speciation in different cultivation regimes.
- MeSH
- aminokyseliny analýza metabolismus MeSH
- biomasa MeSH
- Chlorella klasifikace růst a vývoj metabolismus účinky záření MeSH
- fototrofní procesy MeSH
- heterotrofní procesy MeSH
- mikrořasy chemie růst a vývoj metabolismus účinky záření MeSH
- selen analýza metabolismus MeSH
- Publikační typ
- časopisecké články MeSH
The removal of algal organic matter (AOM) is a growing concern for the water treatment industry worldwide. The current study investigates coagulation of non-proteinaceous AOM (AOM after protein separation), which has been minimally explored compared with proteinaceous fractions. Jar tests with either aluminum sulphate (alum) or polyaluminium chloride (PACl) were performed at doses of 0.2-3.0 mg Al per 1 mg of dissolved organic carbon in the pH range 3.0-10.5. Additionally, non-proteinaceous matter was characterized in terms of charge, molecular weight and carbohydrate content to assess the treatability of its different fractions. Results showed that only up to 25% of non-proteinaceous AOM can be removed by coagulation under optimized conditions. The optimal coagulation pH (6.6-8.0 for alum and 7.5-9.0 for PACl) and low surface charge of the removed fraction indicated that the prevailing coagulation mechanism was adsorption of non-proteinaceous matter onto aluminum hydroxide precipitates. The lowest residual Al concentrations were achieved in very narrow pH ranges, especially in the case of PACl. High-molecular weight saccharide-like organics were amenable to coagulation compared to low-molecular weight (<3 kDa) substances. Their high content in non-proteinaceous matter (about 67%) was the reason for its low removal. Comparison with our previous studies implies that proteinaceous and non-proteinaceous matter is coagulated under different conditions due to the employment of diverse coagulation mechanisms. The study suggests that further research should focus on the removal of low-molecular weight AOM, reluctant to coagulate, with other treatment processes to minimize its detrimental effect on water safety.
The aim of this study is to identify the optimum thermal conversion of Chlorella vulgaris with neuro-evolutionary approach. A Progressive Depth Swarm-Evolution (PDSE) neuro-evolutionary approach is proposed to model the Thermogravimetric analysis (TGA) data of catalytic thermal degradation of Chlorella vulgaris. Results showed that the proposed method can generate predictions which are more accurate compared to other conventional approaches (>90% lower in Root Mean Square Error (RMSE) and Mean Bias Error (MBE)). In addition, Simulated Annealing is proposed to determine the optimal operating conditions for microalgae conversion from multiple trained ANN. The predicted optimum conditions were reaction temperature of 900.0 °C, heating rate of 5.0 °C/min with the presence of HZSM-5 zeolite catalyst to obtain 88.3% of Chlorella vulgaris conversion.
- MeSH
- Chlorella vulgaris * MeSH
- katalýza MeSH
- mikrořasy * MeSH
- neuronové sítě (počítačové) MeSH
- teplota MeSH
- Publikační typ
- časopisecké články MeSH
We have worked out a rapid 1-day test based on photosynthesis measurements to estimate suitable growth temperature of microalgae cultures. To verify the proposed procedure, several microalgae-Chlorella, Nostoc, Synechocystis, Scenedesmus, and Cylindrospermum-were cultured under controlled laboratory conditions (irradiance, temperature, mixing, CO2, and nutrient supply) to find the optima of photosynthetic activity using the range between 15 and 35 °C. These activities were recorded at each temperature step after 2 h of acclimation which should be sufficient as oxygen production and the PQ cycle are regulated by fast processes. Photosynthetic activity was measured using three techniques-oxygen production/respiration, saturating pulse analysis of fluorescence quenching, and fast fluorescence induction kinetics-to estimate the temperature optima which should correspond to high growth rate. We measured all variables that might have been directly related to growth-photosynthetic oxygen evolution, maximum photochemical yield of PSII, Fv/Fm, relative electron transport rate rETRmax, and the transients Vj and Vi determined by fast fluorescence induction curves. When the temperature optima for photosynthetic activity were verified in growth tests, we found good correlation. For most of tested microalgae strains, temperature around 30 °C was found to be the most suitable at this setting. We concluded that the developed test can be used as a rapid 1-day pre-screening to estimate a suitable growth temperature of microalgae strains before they are cultured in a pilot scale.
- MeSH
- Chlorella růst a vývoj metabolismus účinky záření MeSH
- fotosyntéza MeSH
- kinetika MeSH
- kultivační techniky metody MeSH
- kyslík metabolismus MeSH
- mikrořasy růst a vývoj metabolismus účinky záření MeSH
- Scenedesmus růst a vývoj metabolismus účinky záření MeSH
- sinice růst a vývoj metabolismus účinky záření MeSH
- světlo MeSH
- teplota MeSH
- Publikační typ
- časopisecké články MeSH
- hodnotící studie MeSH